Rough-country RC610 Manuel d'utilisateur télécharger pdf

Jeep YJ 2” Body Lift

Thank you for choosing Rough Country for all your suspension needs.

This body lift fits both manual and Automatic equipped vehicles!!!

Refer to last page of this Instruction sheet for Automatic transmission bracket installation.

Rough Country recommends a certified technician install this system. In addition to these instructions, professional

knowledge of disassembly and reassembly procedures as well as post installation checks must be known. Attempts to

install this system without this knowledge and expertise may jeopardize the integrity and/or operating safety of the vehi-

cle.

Please read the instructions before beginning the installation. Check the kit hardware against the Kit Contents shown.

Be sure you have all needed parts and know where they go. If there are any questions about the installation or installa-

tion steps call our tech line at 800-222-7023.

PRODUCT USE INFORMATION

As a general rule, the taller a vehicle is, the easier it will roll. Offset, as much as possible, what is lost in rollover resis-

tance by increasing tire track width. In other words, go "wide" as you go "tall". Many sportsmen remove their mud tires

after hunting season and install ones more appropriate for street driving; always use as wide a tire and wheel combina-

tion as possible to enhance vehicle stability.

Seat belts and shoulder harnesses should be worn at all times. Avoid situations where a side rollover may occur. Gener-

ally, braking performance and capability are decreased when significantly larger/heavier tires and wheels are used. Take

this into consideration while driving.

Do not add, alter, or fabricate any factory or after-market parts to increase vehicle

height over the intended height of the Rough Country product purchased. Mixing component brands is not recom-

mended. Rough Country makes no claims regarding lifting devices and excludes any and all implied claims. We will not

be responsible for any product that is altered.

If you have any questions concerning the design, function, and/or correct use of our products please contact one of our

customer service representatives us at 800-222-7023.

NOTICE TO DEALER AND VEHICLE OWNER

Any vehicle equipped with any Rough Country product should have a “Warning to Driver” decal installed on the

inside of the windshield or on the vehicle’s dash. The decal should act as a constant reminder for whoever is oper-

ating the vehicle of its unique handling characteristics.

INSTALLING DEALER - it is your responsibility to install the warning decal and forward these installation instructions on

to the vehicle owner for review. These instructions should be kept in the vehicle for its service life.

IMPORTANT PRE—INSTALLATION INSTRUCTIONS

Prior to beginning this installation it is always good to use a penetrating oil and spray all body mount hardware

that will be removed. Typically the stock body bushings will need to be checked to ensure they are in good con-

dition. If the stock body bushings are cracked or deteriorated they must be replaced. This should be performed

as the body lift is installed. Failure to perform this maintenance could jeopardize the operating safety of the ve-

hicle.

Floor Jack

Jack Stands

Wood Blocks

3/8” Socket / Wrench

7/16” Socket / Wrench

1/2” Socket / Wrench

5/8” Socket / Wrench

3/4” Socket / Wrench

Drill Motor

1/4” Drill Bit

11/32” Drill Bit

92RC61000

Hammer

Penetrating Oil

Phillips Screwdriver

Flat Screwdriver

7mm Socket / Wrench

8mm Socket / Wrench

13mm Socket / Wrench

16mm Socket / Wrench

19mm Socket / Wrench

Tools Needed:

1 2 3 4 5 6 7 8

Jeep YJ 2” Body Lift 1

Résumé du contenu

Page 1 - Jeep YJ 2” Body Lift

Jeep YJ 2” Body Lift Thank you for choosing Rough Country for all your suspension needs. This body lift fits both manual and Automatic equipped vehi

Page 2

1 1 1 1 1 1 2 2 2 2 2 Kit Includes: 6-2” x 3” Diameter Body Pucks (A) 5-2” x 2” Diameter Body Puck (B) 6-Radiator Shroud Drop Brackets (C) 2-

Page 3

INSTALLATION INSTRUCTIONS 1. Disconnect the negative battery cable using 1/2 wrench. 2. Remove plastic jeep cover from front of vehicle using 3/8 wr

Page 4

10. Move parking brake cable over exhaust hanger to allow the body to be jacked. See Photo 7. 11. Using a 3/4 wrench to loosen the lock nut securing t

Page 5

18. Repeat installation of the body pucks for opposite side. 19. Install the new front bump stop extension under the bump stop on radiator core suppor

Page 6

29. Install the .25” self tapping bolt into supplied radiator drop brackets using a deep well 7mm socket and hammer, by striking the bracket and pushi

Page 7

34. Reinstall fan shroud and power steering reservoir using stock hardware. Use a 1/2” socket to tighten bolts. Make sure fan spins without contacting

Page 8

POST INSTALLATION INSTRUCTIONS 1. Check all fasteners for proper torque. Check to ensure there is adequate clearance between all rotating, mobile,

Commentaires sur ces manuels

Pas de commentaire

Rough-country RC610 Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Rough-country RC610. Rough Country RC610 User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la voiture Rough-country RC610